Y22dth po340 camshaft position sensor malfunction

[GHz]

Hi all,
This will be my first post, also English is not my first language, so please correct me if/when I am wrong.
Recently got P0340 error on Signum 2.2 DTI non starter. Have been looking around for a new pump(VP44 PSG16) and find out they they are quiet expensive (plus labour) and have to be reprogrammed after replacing. So decided to give it a go and try to replace this sensor in the pump myself. There is not much places where sensor can be bought and they are also not cheap. Older pump VP44 PSG5 using same sensor, just a bit different ribbon cable. Sourced one on local scrape yard from Focus TDDI(easiest to remove, pump just in front, inlet in rear).

DSC_8930.jpg
DSC_8938.jpg

Scraped off lacquer and cleaned exposed wires, applied some solder on it and pulled them off from plastic (meant to leave them on it, but find it easier to solder later on). Done same from pump side but without peeling wires off plastic. (it it does makes sence)

DSC_8942.jpg
DSC_8936.jpg
DSC_8946.jpg
DSC_8948.jpg

Matched length of cable, stick two ends together and just solder them one by one.

DSC_8949.jpg
DSC_8951.jpg
DSC_8958.jpg
DSC_8961.jpg
DSC_8963.jpg

In the end cleaned a bit around, between wires and excess of flus and solder. Tested connections from sensor up to pump connection, applied some super glue to strengthen new connection, then covered with layer of high temp. fuel resistant silicone. Fitted all back (cleaned inlet at the same time), then system bleed and car purrs happily again.
I know it's not most elegant way to do that, but it worked (don't know for how long though) and saved me lot's of £.
Maybe someone will find this useful.

Anyone have blocked EGR on those? any suggestions of where to blank it off?

Thanks,
Pavel

[paulvectrac]

Thats brilliant well done mate saves lits of pennys

[GHz]

Forgot to mention about prices, I bought 2 sensors from scrapie (just in case), with some other plastics and couple of screws paid 15£

[bembo449]

crickey , thats fab knowledge to have , ive made notes ! good job

[GHz]

Here is list of cars with VP44 pump where sensor can be obtained, as posted before, easiest one is Focus, straight access to pump.

Make	Type	Pump number	Capacity	Power kw	Year	Engine number
AUDI	A4 2.5 TDI	0 470 506 002	2.5	110	08/1997-06/2000	AFB
AUDI	A4 2.5 TDI Avant	0 470 506 002	2.5	110	11/1997-06/2000	AFB
AUDI	A4 2.5 TDI Avant quattro	0 470 506 002	2.5	110	11/1997-06/2000	AFB
AUDI	A4 2.5 TDI quattro	0 470 506 002	2.5	110	11/1997-06/2000	AFB
AUDI	A6 2.5 TDI	0 470 506 002	2.5	110	04/1997-05/2000	AFB
AUDI	A6 2.5 TDI Avant	0 470 506 002	2.5	110	02/1998-05/2000	AFB
AUDI	A6 2.5 TDI Avant quattro	0 470 506 002	2.5	110	02/1998-05/2000	AFB
AUDI	A6 2.5 TDI quattro	0 470 506 002	2.5	110	07/1997-05/2000	AFB
AUDI	A8 2.5 TDI	0 470 506 002	2.5	110	06/1997-04/2000	AFB
AUDI	A8 2.5 TDI quattro	0 470 506 002	2.5	110	06/1997-06/2000	AFB
AUDI	A4 2.5 TDI	0 470 506 006	2.5	110	07/1998- 10/2000	AKN
AUDI	A4 2.5 TDI Avant	0 470 506 006	2.5	110	08/1998-09/2001	AKN
AUDI	A4 2.5 TDI Avant quattro	0 470 506 006	2.5	110	07/1998-07/1999	AKN
AUDI	A4 2.5 TDI quattro	0 470 506 006	2.5	110	02/1999- 10/2000	AKN
AUDI	A6 2.5 TDI	0 470 506 006	2.5	110	11/1998-06/1999	AKN
AUDI	A6 2.5 TDI Avant	0 470 506 006	2.5	110	11/1998-04/2001	AKN
AUDI	A6 2.5 TDI Avant quattro	0 470 506 006	2.5	110	11/1998-06/1999	AKN
AUDI	A6 2.5 TDI quattro	0 470 506 006	2.5	110	11/1998-06/1999	AKN
AUDI	A8 2.5 TDI	0 470 506 006	2.5	110	11/1997-09/2002	AKN
AUDI	A8 2.5 TDI quattro	0 470 506 006	2.5	110	03/1998-04/1999	AKN
AUDI	A4 2.5 TDI	0 470 506 010	2.5	110	07/1998- 10/2000	AKN
AUDI	A4 2.5 TDI Avant	0 470 506 010	2.5	110	08/1998-09/2001	AKN
AUDI	A4 2.5 TDI Avant quattro	0 470 506 010	2.5	110	07/1998-07/1999	AKN
AUDI	A4 2.5 TDI quattro	0 470 506 010	2.5	110	02/1999- 10/2000	AKN
AUDI	A6 2.5 TDI	0 470 506 010	2.5	110	11/1998-06/1999	AKN
AUDI	A6 2.5 TDI Avant	0 470 506 010	2.5	110	11/1998-04/2001	AKN
AUDI	A6 2.5 TDI Avant quattro	0 470 506 010	2.5	110	11/1998-06/1999	AKN
AUDI	A6 2.5 TDI quattro	0 470 506 010	2.5	110	11/1998-06/1999	AKN
AUDI	A8 2.5 TDI	0 470 506 010	2.5	110	11/1997-09/2002	AKN
AUDI	A8 2.5 TDI quattro	0 470 506 010	2.5	110	03/1998-04/1999	AKN
AUDI	A6 2.5 TDI	0 470 506 016	2.5	132	10/1999-08/2003	AKE
AUDI	A6 2.5 TDI Avant	0 470 506 016	2.5	132	10/1999-08/2003	AKE
AUDI	A6 2.5 TDI AvantAII	0 470 506 016	2.5	132	05/2000 - 05/2003	AKE
AUDI	A6 2.5 TDI Avant quattro	0 470 506 016	2.5	132	10/1999-08/2003	AKE
AUDI	A6 2.5 TDI quattro	0 470 506 016	2.5	132	10/1999-08/2003	AKE
AUDI	A8 2.5 TDI	0 470 506 016	2.5	132	05/2000 - 09/2002	AKE
AUDI	A8 2.5 TDI quattro	0 470 506 016	2.5	132	11/1999-09/2002	AKE
AUDI	A4 2.5 TDI	0 470 506 030	2.5	114	04/2001 -06/2002	AYM
AUDI	A4 2.5 TDI	0 470 506 030	2.5	120	07/2002 - 05/2003	BFC
AUDI	A4 2.5 TDI	0 470 506 030	2.5	120	06/2003-12/2004	BCZ
AUDI	A4 2.5 TDI Avant	0 470 506 030	2.5	114	09/2001 - 06/2002	AYM
AUDI	A4 2.5 TDI Avant	0 470 506 030	2.5	120	07/2002 - 05/2003	BFC
AUDI	A4 2.5 TDI Avant	0 470 506 030	2.5	120	06/2003-12/2004	BCZ
AUDI	A4 2.5 TDI Cabriolet	0 470 506 030	2.5	120	08/2002 - 05/2003	BFC
AUDI	A4 2.5 TDI Cabriolet	0 470 506 030	2.5	120	06/2003- 12/2005	BCZ
AUDI	A6 2.5 TDI	0 470 506 030	2.5	114	06/2001 - 06/2002	AYM
AUDI	A6 2.5 TDI	0 470 506 030	2.5	120	07/2002 - 05/2003	BFC
AUDI	A6 2.5 TDI	0 470 506 030	2.5	120	11/2002-05/2004	BCZ
AUDI	A6 2.5 TDI Avant	0 470 506 030	2.5	114	06/2001 - 06/2002	AYM
AUDI	A6 2.5 TDI Avant	0 470 506 030	2.5	120	07/2002 - 08/2003	BFC
AUDI	A6 2.5 TDI Avant	0 470 506 030	2.5	132	11/2002-01/2005	BCZ
AUDI	A6 2.5 TDI Avant Ali	0 470 506 030	2.5	120	06/2003 - 08/2005	BCZ
AUDI	A4 2.5 TDI	0 470 506 033	2.5	120	06/2003-12/2004	BCZ
AUDI	A4 2.5 TDI Avant	0 470 506 033	2.5	120	06/2003-12/2004	BCZ
AUDI	A4 2.5 TDI Avant qua	0 470 506 033	2.5	132	09/2001 - 05/2003	AKE
AUDI	A4 2.5 TDI Avant qua	0 470 506 033	2.5	132	11/2002-12/2004	BAU
AUDI	A4 2.5 TDI Cabriolet	0 470 506 033	2.5	120	06/2003 -12/2005	BCZ
AUDI	A4 2.5 TDI quattro	0 470 506 033	2.5	132	12/2000-05/2003	AKE
AUDI	A4 2.5 TDI quattro	0 470 506 033	2.5	132	11/2002-12/2004	BAU
AUDI	A6 2.5 TDI	0 470 506 033	2.5	132	10/1999-08/2003	AKE
AUDI	A6 2.5 TDI	0 470 506 033	2.5	132	11/2002-05/2004	BAU
AUDI	A6 2.5 TDI Avant	0 470 506 033	2.5	132	10/1999-08/2003	AKE
AUDI	A6 2.5 TDI Avant	0 470 506 033	2.5	132	11/2002-01/2005	BAU
AUDI	A6 2.5 TDI AvantAII	0 470 506 033	2.5	132	06/2003 - 08/2005	BAU
AUDI	A6 2.5 TDI Avant qua	0 470 506 033	2.5	132	10/1999-08/2003	AKE
AUDI	A6 2.5 TDI Avant qua	0 470 506 033	2.5	132	02/2003 - 01/2005	BAU
AUDI	A6 2.5 TDI quattro	0 470 506 033	2.5	132	10/1999-08/2003	AKE
AUDI	A6 2.5 TDI quattro	0 470 506 033	2.5	132	02/2003 - 05/2004	BAU
AUDI	A4 2.5 TDI	0 470 506 037	2.5	120	06/2003 - 12/2004	BDG
AUDI	A4 2.5 TDI	0 470 506 037	2.5	120	11/2004-05/2006	BDG
AUDI	A4 2.5 TDI Avant	0 470 506 037	2.5	120	06/2003 -12/2004	BDG
AUDI	A4 2.5 TDI Avant	0 470 506 037	2.5	120	11/2004-	BDG
AUDI	A4 2.5 TDI Cabriolet	0 470 506 037	2.5	120	06/2003 -12/2005	BDG
AUDI	A6 2.5 TDI	0 470 506 037	2.5	120	11/2002-05/2004	BDG
AUDI	A6 2.5 TDI Avant	0 470 506 037	2.5	132	11/2002-01/2005	BDG
BMW	320 d E46	0 470 504 005	2	100	04/1998-09/2001	20 4D 1
BMW	320 d Touring E46	0 470 504 005	2	100	04/1998-09/2001	20 4D 1
BMW	320 d E46	0 470 504 020	2	100	04/1998 - 09/2001	20 4D 1
BMW	320 d Touring E46	0 470 504 020	2	100	10/1999 - 09/2001	20 4D 1
BMW	520 d E39	0 470 504 020	2	100	04/2000 - 07/2003	20 4D 1
BMW	520 d Touring E39	0 470 504 020	2	100	04/2000 - 07/2003	20 4D 1
BMW	318 d E46	0 470 504 025	2	85	09/2001 - 03/2003	20 4D 1
BMW	318 d Touring E46	0 470 504 025	2	85	03/2002 - 03/2003	20 4D 1
CHEVROLET	Astra 2.0 GLS TD 16v	0 470 504 011	2	74	09/2000-01/2004	Y 20 DTH
CHEVROLET	Astra 2.0 GLS TD 16v	0 470 504 015	2	74	09/2000-01/2004	Y 20 DTH
DODGE	CUMMINS RAM 3500	0 470 506 027	5.9	160	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 027	5.9	172	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 029	5.9	119	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 029	5.9	142	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 029	5.9	160	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 029	5.9	172	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 029	5.9	187	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 029	5.9	205	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 021	5.9	180	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 022	5.9	172	05/1998-12/2002	ISB
DODGE	CUMMINS RAM 3500	0 470 506 028	5.9	180	05/1998-12/2002	ISB
FORD	Fiesta IV 1.8 TD	0 470 004 007	1.8	55	02/2000-12/2002	RTN
FORD	Fiesta IV 1.8 TD	0 470 004 007	1.8	55	02/2000-12/2002	RTP
FORD	Fiesta IV 1.8 TD	0 470 004 007	1.8	55	02/2000-12/2002	RTQ
FORD	Fiesta IV 1.8 TD Courier	0 470 004 007	1.8	55	02/2000-12/2002	RTN
FORD	Fiesta IV 1.8 TD Courier	0 470 004 007	1.8	55	02/2000-12/2002	RTP
FORD	Fiesta IV 1.8 TD Courier	0 470 004 007	1.8	55	02/2000 -12/2002	RTQ
FORD	Focus I 1.8 TDDi	0 470 004 007	1.8	55	01/1999-05/2005	BHDA
FORD	Focus I 1.8 TDDi	0 470 004 007	1.8	55	01/1999-05/2005	BHDB
FORD	Focus I 1.8 TDDi	0 470 004 007	1.8	66	01/1999-05/2005	C9D...
FORD	Focus I 1.8 TDDi	0 470 004 007	1.8	66	01/1999-05/2005	C9D...
FORD	Focus I 1.8 TDDi	0 470 004 007	1.8	66	01/1999-05/2005	C9DA
FORD	Focus I 1.8 TDDi	0 470 004 007	1.8	66	01/1999-05/2005	C9DC
FORD	Focus I 1.8 TDDi Turbo	0 470 004 007	1.8	55	08/1999-05/2005	BHDA
FORD	Focus I 1.8 TDDi Turbo	0 470 004 007	1.8	55	08/1999-05/2005	BHDB
FORD	Focus I 1.8 TDDi Turbo	0 470 004 007	1.8	66	01/1999-05/2005	C9DA
FORD	Focus I 1.8 TDDi Turbo	0 470 004 007	1.8	66	01/1999-05/2005	C9DB
FORD	Focus I 1.8 TDDi Turbo	0 470 004 007	1.8	66	01/1999-05/2005	C9DC
FORD	Focus Sedan 1.8 Turbo	0 470 004 007	1.8	66	09/2000 -	C9DC
FORD	Fiesta IV 1.8 TD	0 470 004 008	1.8	55	02/2000 - 12/2002	RTN
FORD	Fiesta IV1.8TD	0 470 004 008	1.8	55	02/2000-12/2002	RTP
FORD	Fiesta IV 1.8 TD	0 470 004 008	1.8	55	02/2000-12/2002	RTQ
FORD	Fiesta IV1.8TD Courier	0 470 004 008	1.8	55	02/2000-12/2002	RTN
FORD	Fiesta IV1.8TD Courier	0 470 004 008	1.8	55	02/2000-12/2002	RTP
FORD	Fiesta IV 1.8 TD Courier	0 470 004 008	1.8	55	02/2000-12/2002	RTQ
FORD	Focus I 1.8 TDDi	0 470 004 008	1.8	55	01/1999-05/2005	BHDA
FORD	Focus I 1.8 TDDi	0 470 004 008	1.8	55	01/1999-05/2005	BHDB
FORD	Focus I 1.8 TDDi	0 470 004 008	1.8	66	01/1999-05/2005	C9D...
FORD	Focus I 1.8 TDDi	0 470 004 008	1.8	66	01/1999-05/2005	C9D...
FORD	Focus I 1.8 TDDi	0 470 004 008	1.8	66	01/1999-05/2005	C9DA
FORD	Focus I 1.8 TDDi	0 470 004 008	1.8	66	01/1999-05/2005	C9DC
FORD	Focus I 1.8 TDDi Turbo	0 470 004 008	1.8	55	08/1999-05/2005	BHDA
FORD	Focus I 1.8 TDDi Turbo	0 470 004 008	1.8	55	08/1999-05/2005	BHDB
FORD	Focus I 1.8 TDDi Turbo	0 470 004 008	1.8	66	01/1999-05/2005	C9DA
FORD	Focus I 1.8 TDDi Turbo	0 470 004 008	1.8	66	01/1999-05/2005	C9DB
FORD	Focus I 1.8 TDDi Turbo	0 470 004 008	1.8	66	01/1999-05/2005	C9DC
FORD	Transit Connect 1.8	0 470 004 008	1.8	55	05/2002 -	BHPA
FORD	Transit Connect 1.8	0 470 004 008	1.8	55	05/2002 -	BHPB
FORD	Transit Tourneo Connect	0 470 004 008	1.8	55	05/2002 -	BHPA
FORD	Transit Tourneo Connect	0 470 004 008	1.8	55	05/2002 -	BHPB
FORD	Transit Euroline 2.0	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit FT 240 K/S 2	0 470 004 012	2	55	08/2000 - 04/2006	D3FA
FORD	Transit FT 240 K/S 2	0 470 004 012	2	63	08/2000 - 04/2006	F3FA
FORD	Transit FT 260 K/S 2	0 470 004 012	2	55	08/2000 - 04/2006	D3FA
FORD	Transit FT 260 K/S 2	0 470 004 012	2	63	08/2000 - 04/2006	F3FA
FORD	Transit FT 260 K/S 2	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit FT 260 K/S 2	0 470 004 012	2.4	66	04/2001 - 04/2006	D2F...
FORD	Transit FT 280 K/S 2	0 470 004 012	2	55	08/2000 - 04/2006	D3FA
FORD	Transit FT 280 K/S 2	0 470 004 012	2	63	08/2000 - 04/2006	F3FA
FORD	Transit FT 280 K/S 2	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit FT 280 K/S 2	0 470 004 012	2.4	66	04/2001 - 04/2006	D2F...
FORD	Transit FT 280 L 2.4	0 470 004 012	2.4	55	01/2000-09/2003	F4FA
FORD	Transit FT 280 L 2.4	0 470 004 012	2.4	66	01/2000 - 04/2006	D2F...
FORD	Transit FT 280 M 2.0	0 470 004 012	2	55	08/2000 - 04/2006	D3FA
FORD	Transit FT 280 M 2.0	0 470 004 012	2	63	08/2000 - 04/2006	F3FA
FORD	Transit FT 280 M 2.0	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit FT 280 M 2.4	0 470 004 012	2.4	66	04/2001 - 04/2006	D2F...
FORD	Transit FT 300 K/S 2	0 470 004 012	2	55	08/2000 - 04/2006	D3FA
FORD	Transit FT 300 K/S 2	0 470 004 012	2	63	08/2000 - 04/2006	F3FA
FORD	Transit FT 300 K/S 2	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit FT 300 L 2.0	0 470 004 012	2	55	08/2000 - 04/2006	D3FA
FORD	Transit FT 300 L 2.0	0 470 004 012	2	63	08/2000 - 04/2006	F3FA
FORD	Transit FT 300 L 2.0	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit FT 300 M 2.0	0 470 004 012	2	55	08/2000 - 04/2006	D3FA
FORD	Transit FT 300 M 2.0	0 470 004 012	2	63	08/2000 - 04/2006	F3FA
FORD	Transit FT 300 M 2.0	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit FT 330 K/S 2	0 470 004 012	2	74	08/2003 - 04/2006	ABFA
FORD	Transit FT 330 K/S 2	0 470 004 012	2.4	55	01/2000-09/2003	F4FA
FORD	Transit FT 330 K/S 2	0 470 004 012	2.4	66	01/2000-04/2006	D2F...
FORD	Transit FT 330 L 2.0	0 470 004 012	2	74	08/2003 - 04/2006	ABFA
FORD	Transit FT 330 L 2.4	0 470 004 012	2.4	55	01/2000-09/2003	F4FA
FORD	Transit FT 330 L 2.4	0 470 004 012	2.4	66	01/2000 - 04/2006	D2F...
FORD	Transit FT 330 M 2.0	0 470 004 012	2	74	08/2003 - 04/2006	ABFA
FORD	Transit FT 330 M 2.4	0 470 004 012	2.4	55	01/2000-09/2003	F4FA
FORD	Transit FT 330 M 2.4	0 470 004 012	2.4	66	01/2000-04/2006	D2F...
FORD	Transit FT 350 EL 2.	0 470 004 012	2	74	08/2003 - 04/2006	ABFA
FORD	Transit FT 350 EL 2.	0 470 004 012	2.4	55	01/2000 - 09/2003	F4FA
FORD	Transit FT 350 EL 2.	0 470 004 012	2.4	66	01/2000-04/2006	D2F...
FORD	Transit FT 350 L 2.0	0 470 004 012	2	74	08/2003 - 04/2006	ABFA
FORD	Transit FT 350 L 2.4	0 470 004 012	2.4	55	01/2000-09/2003	F4FA
FORD	Transit FT 350 L 2.4	0 470 004 012	2.4	66	01/2000-04/2006	D2F...
FORD	Transit FT 350 M 2.0	0 470 004 012	2	74	08/2003 - 04/2006	ABFA
FORD	Transit FT 350 M 2.4	0 470 004 012	2.4	55	01/2000 - 09/2003	F4FA
FORD	Transit FT 350 M 2.4	0 470 004 012	2.4	66	01/2000 - 04/2006	D2F...
FORD	Transit FT 430 EL 2.	0 470 004 012	2.4	55	08/2002 - 09/2003	F4FA
FORD	Transit FT 430 EL 2.	0 470 004 012	2.4	66	08/2002 - 04/2006	D2F...
FORD	Transit FT 430 M 2.4	0 470 004 012	2.4	55	08/2002 - 09/2003	F4FA
FORD	Transit FT 430 M 2.4	0 470 004 012	2.4	66	08/2002 - 04/2006	D2F...
FORD	Transit Nugget2.0 T	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit Tourneo 2.0	0 470 004 012	2	74	08/2000 - 04/2006	ABFA
FORD	Transit FT 330 K/S 2	0 470 504 018	2.4	88	01/2000-04/2006	D4FA
FORD	Transit FT 330 K/S 2	0 470 504 018	2.4	92	01/2000 - 04/2006	DOFA
FORD	Transit FT 330 L 2.4	0 470 504 018	2.4	88	01/2000 - 04/2006	D4FA
FORD	Transit FT 330 L 2.4	0 470 504 018	2.4	92	01/2000-04/2006	DOFA
FORD	Transit FT 330 M 2.4	0 470 504 018	2.4	88	01/2000-04/2006	D4FA
FORD	Transit FT 330 M 2.4	0 470 504 018	2.4	92	01/2000 - 04/2006	DOFA
FORD	Transit FT 350 EL 2.	0 470 504 018	2.4	92	01/2000 - 04/2006	DOFA
FORD	Transit FT 350 L 2.4	0 470 504 018	2.4	88	01/2000 - 04/2006	D4FA
FORD	Transit FT 350 L 2.4	0 470 504 018	2.4	92	01/2000 - 04/2006	DOFA
FORD	Transit FT 350 M 2.4	0 470 504 018	2.4	88	01/2000 - 04/2006	D4FA
FORD	Transit FT 350 M 2.4	0 470 504 018	2.4	92	01/2000-04/2006	DOFA
FORD	Transit FT 430 EL 2.	0 470 504 018	2.4	92	08/2002 - 04/2006	DOFA
FORD	Mondeo III 2.0 TDDi	0 470 504 024	2	85	10/2000 - 08/2002	D6BA
FORD	Mondeo III 2.0 TDDi	0 470 504 024	2	85	10/2000- 08/2002	D6BA
FORD	Mondeo III 2.0 TDDi	0 470 504 024	2	85	10/2000- 08/2002	D6BA
FORD	Mondeo III 2.0 TDDi	0 470 504 036	2	85	10/2000- 08/2002	D6BA
FORD	Mondeo III 2.0 TDDi	0 470 504 036	2	85	10/2000- 08/2002	D6BA
FORD	Mondeo III 2.0 TDDi	0 470 504 036	2	85	10/2000- 08/2002	D6BA
ISUZU	KB 3.0 TDi	0 470 504 038	3	96	07/2002 -12/2004	4JH1
ISUZU	KB 3.0 TDi	0 470 504 038	3	96	07/2004 -11/2007	4JH1-TC
MAN	10.145 L L2000	0 470 504 017	4.6	103	07/2001 - 06/2002	D 0834 LFL02
MAN	8.185 L L2000	0 470 504 017	4.6	132	09/2000 - 08/2002	D 0834 LFL03
MAN	8.185 LL L2000	0 470 504 017	4.6	132	09/2000 - 08/2002	D 0834 LFL03
MAN	9.185 L L2000	0 470 504 017	4.6	132	09/2000 - 08/2002	D 0834 LFL03
MAN	Ale	0 470 504 017	4.6		02/2000-12/2001	D 0834 LOH01
MAN	LE 10.150 F, FL L2000 Evolution	0 470 504 017	4.6	110	06/2004 - 06/2005	D 0834 LFL04
MAN	LE 10.180 F, FA L2000 Evolution	0 470 504 017	4.6	132	09/2002 -	D 0834 LFL03
MAN	LE 10.180 F, FL L2000 Evolution	0 470 504 017	4.6	132	09/2002 - 06/2005	D 0834 LFL03
MAN	LE 12.180 F, FL M2000L Evolution	0 470 504 017	4.6	132	09/2002- 12/2005	D 0834 LFL03
MAN	LE 140C F, FL L2000 Evolution	0 470 504 017	4.6	103	07/2001 - 08/2002	D 0834 LFL02
MAN	LE 1400 F, FL L2000 Evolution	0 470 504 017	4.6	103	07/2001 - 08/2002	D 0834 LFL02
MAN	LE 15.180 F, FL M2000L Evolution	0 470 504 017	4.6	132	09/2002 - 03/2005	D 0834 LFL03
MAN	LE 180B F, FL M2000L Evolution	0 470 504 017	4.6	132	07/2001 - 08/2002	D 0834 LFL03
MAN	LE 180C F, FA L2000 Evolution	0 470 504 017	4.6	132	07/2001 - 08/2002	D 0834 LFL03
MAN	LE 180C F, FL L2000 Evolution	0 470 504 017	4.6	132	09/2000 - 08/2002	D 0834 LFL03
MAN	LE 180C F, FL L2000 Evolution	0 470 504 017	4.6	132	07/2001 - 08/2002	D 0834 LFL03
MAN	LE 180C F, FL L2000 Evolution	0 470 504 017	4.6	132	07/2001 - 08/2002	D 0834 LFL03
MAN	LE 180C F, FL M2000L Evolution	0 470 504 017	4.6	132	07/2001 - 09/2002	D 0834 LFL03
MAN	LE 8.140 F, FL L2000 Evolution	0 470 504 017	4.6	103	09/2002 - 08/2004	D 0834 LFL02
MAN	LE 8.150 F, FL L2000 Evolution	0 470 504 017	4.6	110	06/2004-12/2005	D 0834 LFL04
MAN	LE 8.180 F, FL L2000 Evolution	0 470 504 017	4.6	132	09/2002-12/2005	D 0834 LFL03
MAN	LE 9.140 F, FL L2000 Evolution	0 470 504 017	4.6	103	09/2002 - 08/2004	D 0834 LFL02
MAN	LE 9.150 F, FL L2000 Evolution	0 470 504 017	4.6	110	06/2004 - 06/2005	D 0834 LFL04
MAN	LE 9.180 F, FL L2000 Evolution	0 470 504 017	4.6	132	09/2002 - 06/2005	D 0834 LFL03
MG	ZR 2.0 Turbodiesel	0 470 004 005	2	74	10/2001- 05/2005	TCie
MG	ZS 2.0 TD	0 470 004 005	2	74	10/2001- 05/2005	TCie
MITSUBISHI	Canter-35 3.0 Turbo	0 470 504 027	3	92	11/2000-	4M42
MITSUBISHI	Canter-35 3.0 Turbo	0 470 504 027	3	92	11/2000-	4M42-0AT
MITSUBISHI	Canter-55 3.0 Turbo	0 470 504 027	3	92	11/2000-	4M42-0AT
NISSAN	Almera 2.2 Diesel Turbo	0 470 504 012	2.2	81	01/2000- 02/2003	YD22DDT
NISSAN	Almera 2.2 Diesel Turbo	0 470 504 012	2.2	81	04/2000 - 03/2001	YD22DDT
NISSAN	Almera Tino 2.2 Diesel	0 470 504 012	2.2	81	05/2000 - 01/2003	YD22DDTI
NISSAN	Almera 2.2 Diesel Turbo	0 470 504 028	2.2	81	01/2000 - 02/2003	YD22DDT
NISSAN	Almera 2.2 Diesel Turbo	0 470 504 028	2.2	81	03/2001 - 02/2003	YD22DDT
NISSAN	Almera Tino 2.2 Diesel	0 470 504 028	2.2	81	05/2000 - 01/2003	YD22DDTI
NISSAN	Frontier ZD30 DD	0 470 504 029	3	78	11/2000-	ZD30E
NISSAN	Frontier ZD30 DDT	0 470 504 038	3	112	11/2001 -	ZD30ET
NISSAN	Patrol GR 3.0 Di	0 470 504 046	3	116	02/2000 -	ZD30DDTI
NISSAN	Patrol GR 3.0 Di	0 470 504 046	3	116	02/2000 -	ZD30DDTI
OPEL	Astra G 1.7 DT	0 470 004 003	1.7	50	03/1998- 08/2000	X 17 DTL
OPEL	Astra G 1.7 DT Caravan	0 470 004 003	1.7	50	03/1998- 08/2000	X 17 DTL
OPEL	Vectra B 2.0 Dl	0 470 504 002	2	60	09/1996- 08/2000	X20 DTL 16VTurb
OPEL	Astra G 2.0 DT	0 470 504 003	2	60	03/1998- 08/2000	X 20 DTL
OPEL	Astra G 2.0 DT Caravan	0 470 504 003	2	60	03/1998- 08/2000	X 20 DTL
OPEL	Astra G 2.0 DTL	0 470 504 003	2	60	09/2000 - 01/2004	Y 20 DTL
OPEL	Astra G 2.0 DTL Caravan	0 470 504 003	2	60	09/2000 - 06/2004	Y 20 DTL
OPEL	Vectra B 2.0 Dl	0 470 504 003	2	60	09/1996- 08/2000	X20 DTL 16VTurb
OPEL	Zafira A 2.0 Dl	0 470 504 003	2	60	03/1999- 08/2000	X 20 DTL Turbo
OPEL	Vectra B 2.0 DTI	0 470 504 004	2	74	09/1997- 08/2003	X 20 DTH
OPEL	Frontera B 2.2 DTI	0 470 504 009	2.2	85	09/1998- 10/2002	X 22 DTH
OPEL	Frontera B 2.2 DTI	0 470 504 009	2.2	88	09/2002 - 09/2004	Y 22 DTH
OPEL	Omega B 2.0 DTI Turbo	0 470 504 009	2	74	09/1997- 08/2000	X 20 DTH
OPEL	Sintra 2.2 TD	0 470 504 009	2.2	85	09/1997- 09/1999	X 20 DTH
OPEL	Astra G 2.0 DT	0 470 504 011	2	60	03/1998- 08/2000	X 20 DTL
OPEL	Astra G 2.0 DT Caravan	0 470 504 011	2	60	03/1998- 08/2000	X 20 DTL
OPEL	Astra G 2.0 DTI	0 470 504 011	2	74	09/2000- 01/2004	Y 20 DTH
OPEL	Astra G 2.0 DTI Caravan	0 470 504 011	2	74	09/2000- 06/2004	Y 20 DTH
OPEL	Astra G 2.0 DTL	0 470 504 011	2	60	09/2000- 01/2004	Y 20 DTL
OPEL	Astra G 2.0 DTL Caravan	0 470 504 011	2	60	09/2000- 06/2004	Y 20 DTL
OPEL	Omega B 2.0 DTI Turbo	0 470 504 011	2	74	09/1997- 08/2000	X 20 DTH
OPEL	Vectra B 2.0 Dl	0 470 504 011	2	60	09/1996- 08/2000	X20 DTL 16VTurb
OPEL	Vectra B 2.0 DTI	0 470 504 011	2	74	09/1997- 08/2003	X 20 DTH
OPEL	Zafira A 2.0 Dl	0 470 504 011	2	60	03/1999- 08/2000	X 20 DTL Turbo
OPEL	Zafira A 2.0 DTI	0 470 504 011	2	74	04/1999- 07/2005	Y 20 DTH Turbo
OPEL	Astra G 2.0 DTI	0 470 504 015	2	74	09/2000-01/2004	Y 20 DTH
OPEL	Astra G 2.0 DTI Caravan	0 470 504 015	2	74	09/2000- 06/2004	Y 20 DTH
OPEL	Vectra B 2.0 DTI	0 470 504 015	2	74	09/2000- 09/2002	Y 20 DTH
OPEL	Zafira A 2.0 DTI	0 470 504 015	2	74	04/1999- 07/2005	Y 20 DTH Turbo
OPEL	Omega B 2.2 DTI	0 470 504 016	2.2	88	06/2000- 09/2003	Y 22 DTH Turbo
OPEL	Vectra B 2.2 DTI	0 470 504 016	2.2	92	09/2000- 09/2002	Y 22 DTR
OPEL	Astra G 2.2 DTI	0 470 504 209	2.2	92	09/2001 - 01/2004	Y 22 DTR
OPEL	Astra G 2.2 DTI Cabrio	0 470 504 209	2.2	92	03/2002 - 08/2005	Y 22 DTR
OPEL	Astra G 2.2 DTI Caravan	0 470 504 209	2.2	92	09/2001 - 06/2004	Y 22 DTR
OPEL	Astra G 2.2 DTI Coupe	0 470 504 209	2.2	92	03/2002 - 02/2005	Y 22 DTR
OPEL	Vectra C2.2 DTI	0 470 504 209	2.2	86-92	04/2002 - 09/2005	Y 22 DTR
OPEL	Vectra C 2.2 DTI Caravan	0 470 504 209	2.2	86-92	09/2003 - 09/2005	Y 22 DTR
OPEL	Zafira A 2.2 DTI	0 470 504 209	2.2	92	03/2002 - 07/2005	Y 22 DTR
OPEL	Astra G 2.0 DTI	0 470 504 218	2	74	09/2000 - 01/2004	Y 20 DTH
OPEL	Astra G 2.0 DTI Caravan	0 470 504 218	2	74	09/2000 - 06/2004	Y 20 DTH
OPEL	Zafira A 2.0 DTI	0 470 504 218	2	74	04/1999 - 07/2005	Y 20 DTH Turbo
ROVER	220 2.0 SDI	0 470 004 005	2	77	09/1995 - 03/2000	20T2N
ROVER	25 2.0 iDT	0 470 004 005	2	74	02/2000 - 05/2005	20 T2N-TCie
ROVER	25 2.0 iDT	0 470 004 005	2	83	02/2003 - 05/2005	TCie
ROVER	420 2.0 SDI	0 470 004 005	2	77	10/1995 - 03/2000	20T2N-TCie
ROVER	45 2.0 iDT	0 470 004 005	2	74	02/2000 - 05/2005	20 T2N -TCie
ROVER	45 2.0 iDT	0 470 004 005	2	83	02/2003 - 05/2005	TCie
SAAB	9-3 2.2 16V Turbodiesel	0 470 504 004	2.2	85	03/1998- 10/2000	D223L
SAAB	9-3 2.2 16V Turbodiesel	0 470 504 004	2.2	92	11/2000- 09/2002	D223L
SAAB	9-3 2.2 Coupe 16V Turbo	0 470 504 004	2.2	92	11/2000- 09/2002	D223L
SAAB	9-5 2.2TJD	0 470 504 208	2.2	88	03/2002 -	D223L
SAAB	9-5 2.2 TiD Kombi	0 470 504 208	2.2	88	03/2002 -	D223L
SKODA	Superb 2.5 TDI	0 470 506 030	2.5	114	12/2001 - 08/2003	AYM
VAUXHALL	Astra G 1.7 DT	0 470 004 003	1.7	50	03/1998 -08/2000	X 17 DTL
VAUXHALL	Vectra B 2.0 DI	0 470 504 002	2	60	09/1996 - 08/2000	X20 DTL 16VTurbo
VAUXHALL	Astra G 2.0 DTL	0 470 504 003	2	60	03/1998- 08/2000	X 20 DTL
VAUXHALL	Astra G 2.0 DTL	0 470 504 003	2	60	09/2000 - 08/2005	Y 20 DTL
VAUXHALL	Vectra B 2.0 DI	0 470 504 003	2	60	09/1996- 08/2000	X20 DTL 16VTurbo
VAUXHALL	Zafira A 2.0 DI	0 470 504 003	2	60	03/1999- 08/2000	X 20 DTL
VAUXHALL	Vectra B 2.0 DTI	0 470 504 004	2	74	09/1997- 08/2000	X20 DTH 16VTurbo
VAUXHALL	Frontera B 2.2 DTI	0 470 504 009	2.2	85	09/1998- 09/2004	X 22 DTH
VAUXHALL	Frontera B 2.2 DTI	0 470 504 009	2.2	88	09/1998- 09/2004	Y 22 DTH
VAUXHALL	Omega B 2.0 DTI	0 470 504 009	2	74	09/1997- 08/2000	X 20 DTH Turbo
VAUXHALL	Sintra 2.2 TD	0 470 504 009	2.2	85	09/1997- 09/1999	X 22 DTH Turbo
VAUXHALL	Omega B 2.0 DTI	0 470 504 011	2	74	09/1997-08/2000	X 20 DTH Turbo
VAUXHALL	Vectra B 2.0 DI	0 470 504 011	2	60	09/1996-08/2000	X 22 DTH Turbo
VAUXHALL	Vectra B 2.0 DTI	0 470 504 011	2	74	09/1997-08/2000	X20 DTH 16VTurbo
VAUXHALL	Vectra B 2.0 DTI	0 470 504 015	2	74	09/2000-08/2001	Y20 DTH 16VTurbo
VAUXHALL	Omega B 2.2 DTI	0 470 504 016	2.2	88	06/2000-09/2003	Y 22 DTH Turbo
VAUXHALL	Vectra B 2.2 DTI	0 470 504 016	2.2	92	09/2000-08/2001	Y 22 DTR Turbo
VAUXHALL	Astra G 2.2 DTI	0 470 504 209	2.2	92	09/2001-08/2005	Y 22 DTR
VAUXHALL	Vectra C 2.2 DTI	0 470 504 209	2.2	86-92	04/2002-09/2005	Y 22 DTR
VAUXHALL	Vectra C 2.2 DTI Estat	0 470 504 209	2.2	86-92	09/2003-09/2005	Y 22 DTR
VAUXHALL	Zafira A 2.2 DTI	0 470 504 209	2.2	92	03/2002-06/2005	Y 22 DTR
VOLKSWAGEN	Passat 2.5 TDI	0 470 506 002	2.5	110	08/1998-11/2000	AFB
VOLKSWAGEN	Passat 2.5 TDI Syncro	0 470 506 002	2.5	110	08/1998-11/2000	AFB
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 002	2.5	110	08/1998- 11/2000	AFB
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 002	2.5	110	02/1999- 11/2000	AFB
VOLKSWAGEN	Passat 2.5 TDI	0 470 506 006	2.5	110	08/1998- 11/2000	AKN
VOLKSWAGEN	Passat 2.5 TDI	0 470 506 006	2.5	110	10/2000-05/2003	AKN
VOLKSWAGEN	Passat 2.5 TDI 4 Motion	0 470 506 006	2.5	110	10/2000-01/2003	AKN
VOLKSWAGEN	Passat 2.5 TDI Syncro	0 470 506 006	2.5	110	08/1998- 11/2000	AKN
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 006	2.5	110	05/1999- 11/2000	AKN
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 006	2.5	110	10/2000-05/2003	AKN
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 006	2.5	110	10/2000-01/2003	AKN
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 006	2.5	110	05/1999- 11/2000	AKN
VOLKSWAGEN	Passat 2.5 TDI	0 470 506 010	2.5	110	08/1998- 11/2000	AKN
VOLKSWAGEN	Passat 2.5 TDI	0 470 506 010	2.5	110	10/2000-05/2003	AKN
VOLKSWAGEN	Passat 2.5 TDI 4 Motion	0 470 506 010	2.5	110	10/2000-01/2003	AKN
VOLKSWAGEN	Passat 2.5 TDI Syncro	0 470 506 010	2.5	110	08/1998-11/2000	AKN
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 010	2.5	110	05/1999-11/2000	AKN
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 010	2.5	110	10/2000-05/2003	AKN
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 010	2.5	110	10/2000-01/2003	AKN
VOLKSWAGEN	Passat 2.5 TDI Variant	0 470 506 010	2.5	110	05/1999-11/2000	AKN
VOLKSWAGEN	Passat 2.5 TDI 4 Motion	0 470 506 033	2.5	132	01/2003-05/2005	BAU
VOLKSWAGEN	Passat 2.5 TDI 4 Variant	0 470 506 033	2.5	132	01/2003-05/2005	BAU
VOLVO	FL6 180	0 470 506 017	5.5	132	05/2000 -	D6B180
VOLVO	FL 6 220	0 470 506 017	5.5	162	05/2000 -	D6B220
VOLVO	FL 6 250	0 470 506 017	5.5	184	05/2000 -	D6B250

[peadar]

well done i have never heard of anyone doing a diy job on a vp44 , have you any pics of where the location of the sensor is on the pump
this is 1 for the how 2

[GHz]

well done i have never heard of anyone doing a diy job on a vp44 , have you any pics of where the location of the sensor is on the pump
this is 1 for the how 2

Thanks job is actually easier than it looks like, no special knowledge required.
I do have some more pictures of pump disassemble and other way around (pumps ecu, actual pump stays in a car). I will add some more info tomorrow or Monday then.

[Bectra]

Hi great job do you have any more pictures on disassembling the pump on the car
thx