Oil Level Warning Light issue

[Blagmeister]

Having had my oil level warning light come on intermittently a day or so prior to my 120K service I didn't take too much notice as it was going in anyway. However after getting the car back from the service [its now driving much better] I am still getting the oil level warning light come on when the car is fully warm. There is no problem with the oil level as the car has had a flush and refill as usual.

Any suggestions as to what might be causing it? Duff sender unit perhaps?

Over to you gurus....

Blag

[jonnybravo]

Hi B
allmost certainly the sender,it is the oil level light and not the oil pressure light.just to be sure!

[Blagmeister]

Hi JonnyB

Yes it is the level light and not the pressure light. I had a feeling it would prolly be the sender as the level was ok. Only thing is where to find it? I have got a gut feeling that there might be a sensor in the sump for this which means dropping the sump cover off in which case it can wait until the next service!

[jonnybravo]

what year ,model,engine have you got,

[Blagmeister]

It's an 05 1.9 cdti 150 Elite estate

[Ste]

The OLS on my 1.8 is mounted in the side of the sump on the front. Unclipping the wiring will remove the warning - if you are sure it is erroneous.

[jonnybravo]

yes your right Blagmeister it's a sump off job,straight forward then.

[Ste]

So there is no way of simply disconnecting it without removing the sump? I always hate having to remove sumps on cars, the oil dripping is a pain. I would have a look at the engine bottom end while I was there though, and check all the bolts are all tight.

[glenboy]

Looks like i have the same problem,warning light has come on 3 times in a week and level wasn't low at all,how much of a job is it to remove the sump????

[Ste]

PITA if you ask me. If it was my car, I would disconnect the sensor and check the oil more regularly. IMO it isn't worth the hassle and mess of removing the sump.